Raise the side- 3-11 for seat opening and closing stand or lower it with your foot while procedures. Spark plug wrench To remove a spark plug 3. Use spray oil as a universal cleaner to remove any remaining dirt. If the indicator light does not wise the battery may discharge. Scheduled motorcycle maintenance should occur frequently at regular intervals. Check for oncoming traffic, and then slowly turn the throttle grip on the right in order to take off.
See page 3-2 and 6-15 for more information When the oil change indicator light comes on about the oil change indicator light. V-belt air filter element left 2. Remove the battery and fully the pivoting points of all levers charge it. Record the information on this label in the space provided. Battery cover To charge the battery To access the battery Have a Yamaha dealer charge the 1.
Even with diligent routine maintenance, motorcycles may require periodic repairs. Fuel tank cap page 3-9 7. Fully charge the battery before tities of water or milk and Yamaha dealer charge your installation. The vehicle can now be operated normally. Panel E Panels A and D 4. If any of those more information.
Clean the surface of the spark trode erosion and excessive car-. Routine maintenance and periodic repairs at home will save you money and prolong the life of your motorcycle. Pass the helmet holding cable this will result in poor damp- through the buckle on the helmet ing performance. Pour a teaspoonful of engine Short-term 1. The sidestand switch may be defective. However, they also impose certain limits, which you must accept; even the best scooter does not ignore the laws of physics.
Lubricate all control cables and 8. With proper care and routine maintenance, your motorcycle will provide many years of reliable use. Battery The engine turns over The battery is good. All information in this manual is based on the latest product information at the time of publication. Fold the seat down, and then push it down to lock it in place. Front brake lever page 3-9 4. This routine maintenance should include changing the oil, inspecting the shift linkage — steering — suspension — coolant system — fuel system — drive belts — engine mounts, changing the spark plugs, and replacing the fuel and air filters.
Front storage compartment page 3-14 18. Engine oil drain bolt page 6-13 3. If the engine overheats again, have a The coolant level Yamaha dealer check and repair the cooling system. Have a Yamaha dealer check the vehicle. Coolant level check window page 6-17 13.
Follow all the instructions in the oil into the spark plug bores. Imitation parts may look and then secure it with the bulb like Yamaha parts, but they are often holder. It prolongs the life of your motorcycle. It is less expensive than having a motorcycle repair shop do the maintenance. Rear storage compartment page 3-14 8. In addition, the oil must be changed and the oil filter cartridge replaced at the inter- vals specified in the periodic mainte- nance and lubrication chart. Switch the turn signal off.
The hazard light is used in case of an emergency or to warn other drivers when your scooter is stopped where. Consider the follow- over to one side , otherwise ing tips to reduce fuel consumption: the scooter may skid or over-. Helmet holder page 3-13 9. If there is free play, be replaced. The engine does not start. Place the scooter on a level sur- face and hold it in an upright position. Apply a thin coat of engine oil to 3.
Contents include exploded diagrams and part number lists. In the event that you need to repair your motorcycle, it will likely be easier if you have been doing your own routine maintenance as you will be more familiar with the mechanics of your engine. Be windshield: Do not use strong or on salt-sprayed roads sure to avoid using cloths or cleaners or hard sponges as. Since heat and deposits will cause any spark plug to slowly erode, the spark plugs should be removed and checked in accordance with the periodic maintenance and lubrication. Rear brake lever page 3-9 6.
Avoid hard braking, because the scooter could slide. Having a quality parts manual specific to your motorcycle will help you identify the parts of your motorcycle and assist you during routine maintenance and repair. In order to assure your safety and the efficient functioning of the vehicle, this manual should be read thoroughly. Screw ×2 Panel F Cowling A Cowling B To remove the panel To remove the cowling To remove the cowling Remove the panel screws. Ignition fuse Replacing the fuses 4. If the fuse immediately blows again, have a Yamaha dealer check the electrical system.